Some 2013 – 2015 model year RAV4 vehicles may exhibit a brief shudder intermittently while driving under light loads between approximately 25 and 50 mph. The torque converter and Engine Control Module/ECM (SAE term: Powertrain Control Module/PCM) logic have been modified to reduce the possibility of this condition from occurring. Follow the Repair Procedure below to address this condition.More repair Toyota case,please check it here:Toyota Trouble Repair
Repair Procedure
1.With the vehicle at operating temperature, confirm the condition described in the Introduction.
Is there a brief shudder intermittently present while driving under a light load between
25 – 50 mph?
NOTE
The condition will be most noticeable prior to an upshift.
* YES — Continue to step 2.
* NO—This bulletin does NOT apply. Continue diagnosis using the applicable Repair Manual.
NOTICE
Be sure to follow the procedure below in the order provided to prevent contamination of previously cleaned parts.
2.Drain the ATF from the transaxle by removing the drain plug.
Refer to the Technical Information System (TIS), applicable model and model year
Repair Manual:
* 2013 – 2015 RAV4:
Drivetrain – Automatic Transmission/Transaxle – “U760E / U760F Automatic
Transmission/Transaxle: Automatic Transaxle Fluid: Replacement”
* Remove and replace the torque converter.
Refer to TIS, applicable model and model year Repair Manual:
* 2013 – 2015 RAV4:
Drivetrain – Automatic Transmission/Transaxle – “U760E / U760F Automatic
Transmission/Transaxle: Automatic Transaxle Assembly: Removal”
* With the transaxle installed in the vehicle, remove the transaxle oil pan.
Refer to TIS, applicable model and model year Repair Manual:
* 2013 – 2015 RAV4:
Drivetrain – Automatic Transmission/Transaxle – “U760E / U760F Automatic
Transmission/Transaxle: Valve Body Assembly: Removal”
* Remove and discard the two oil pan magnets and clean the inside of the oil pan by wiping it off with a clean cloth ONLY.
NOTICE
Do NOT use ANY chemical cleaners to clean the inside of the oil pan.
6.Install four NEW magnets as shown.
6
7.Reinstall the oil pan using a NEW oil pan gasket.
Refer to TIS, applicable model and model year Repair Manual:
* 2013 – 2015 RAV4:
Drivetrain – Automatic Transmission/Transaxle – “U760E / U760F Automatic
Transmission/Transaxle: Valve Body Assembly: Installation”
8.Reinstall the drain plug using a NEW drain plug gasket and refill the transaxle with ATF.
Refer to TIS, applicable model and model year Repair Manual:
* 2013 – 2015 RAV4:
Drivetrain – Automatic Transmission/Transaxle – “U760E / U760F Automatic
Transmission/Transaxle: Automatic Transaxle Fluid: Replacement”
9.Check for the Authorized Modifications Label affixed to the vehicle in the locatio shown below. Confirm if the ECM (PCM) calibration has been updated.
Is the calibration ID listed the latest ECM (PCM) calibration?
* YES — Go to step 12.
* NO — Continue to step 10.
7
10.Flash reprogram the ECM (PCM).
NOTE
* The GR8 Battery Diagnostic Station MUST be used in Power Supply Mode to maintain battery voltage at 13.5V while flash reprogramming the vehicle.
* For details on how to use the GR8 Battery Diagnostic Station, refer to the
“GR8 Instruction Manual” located on TIS,
Diagnostics – Tools & Equipment – Battery Diagnostics.
Follow the procedures outlined in Service Bulletin No. T-SB-0012-13, “Techstream ECU Flash
Reprogramming Procedure,” and flash the ECM (PCM) with the NEW calibration file update.
11.Install the Authorized Modifications Label.
Using a permanent marker, enter the following information on the label:
* ECM part number [Refer to the Parts Information section for the NEW PART NUMBER]
* Calibration ID(s) [Refer to the Calibration Information section for the NEWCALIBRATION ID]
* Dealer Code
* Repair Date
* Change Authority [This bulletin number]
B.Affix the Authorized Modifications Label to the vehicle at the location shown in Figure 2.
The Authorized Modifications Label is available through the MDC, P/N 00451-00001-LBL.
12.Perform the Techstream ECT Reset Memory Utility and test drive the vehicle to confirm the repair.
For more information, please follow https://www.obd2.ltd
Comment télécharger? / How to download? viewtopic.php?f=77&t=1294 Comment télécharger? / How to download? viewtopic.php?f=77&t=1294 Comment télécharger? / How to download? viewtopic.php?f=77&t=1294
All Autocom Delphi versions viewtopic.php?f=215&t=22381 VCDS all versions + Loader 03/2022 viewtopic.php?f=203&t=18855 Xentry Passthru 06.2023 Full Keygen + Activation viewtopic.php?t=23252 DTS Monaco 9.02 + Keygen viewtopic.php?f=215&t=22221
Davinci Deluxe v1.0.30 / 2023 Registered viewtopic.php?f=215&t=23174 Tuned file Database STAGE1 STAGE2 STAGE3 20GB viewtopic.php?f=216&t=18029 Multi Editor Tool v2 2023 + Keygen viewtopic.php?f=216&t=22368 Easy Renault v6.1.4 FR + Activator viewtopic.php?f=212&t=22456
WinOLS Damos 2023 collection all car brands viewtopic.php?f=216&t=23669 Car Diagnostic Software Package 81 GB viewtopic.php?f=215&t=23209 Multiecuscan v5.1 + 5.0 + v4.9 / 2024 + Activator viewtopic.php?f=206&t=21696 Haynes Pro Full viewtopic.php?f=215&t=6793
RENAULT DIALOGYS 4.90 Français viewtopic.php?f=199&t=16332 Autodata 3.45 Français et Anglais viewtopic.php?f=202&t=3006 Jpro 2022 v2 + Activator viewtopic.php?f=215&t=24113 ElsaWin 6.0 Multilanguage viewtopic.php?f=190&t=12951
Renault Can Clip v236 + Activator 03.2024 viewtopic.php?f=212&t=24003 MaxiECU2 Full + License viewtopic.php?f=215&t=2393 Toyolex 4 Unlocked no need activation viewtopic.php?f=213&t=23442&p=135735 Immo Doctor v2.1 2023 + Keygen viewtopic.php?f=216&t=22367
Selling / Vente: Activation Launch x431 EasyDiag Golo + ThinkDiag viewtopic.php?f=137&t=14064 Xentry OpenShell 12.2023 HHT (+C3) WIS EPC Vediamo Monaco viewtopic.php?f=196&t=13346 Remote Install BMW ISTA-D, ISTA-P, INPA, E-Sys viewtopic.php?f=137&t=14739
All Autocom Delphi versions viewtopic.php?f=215&t=22381 VCDS all versions + Loader 03/2022 viewtopic.php?f=203&t=18855 Xentry Passthru 06.2023 Full Keygen + Activation viewtopic.php?t=23252 DTS Monaco 9.02 + Keygen viewtopic.php?f=215&t=22221
Davinci Deluxe v1.0.30 / 2023 Registered viewtopic.php?f=215&t=23174 Tuned file Database STAGE1 STAGE2 STAGE3 20GB viewtopic.php?f=216&t=18029 Multi Editor Tool v2 2023 + Keygen viewtopic.php?f=216&t=22368 Easy Renault v6.1.4 FR + Activator viewtopic.php?f=212&t=22456
WinOLS Damos 2023 collection all car brands viewtopic.php?f=216&t=23669 Car Diagnostic Software Package 81 GB viewtopic.php?f=215&t=23209 Multiecuscan v5.1 + 5.0 + v4.9 / 2024 + Activator viewtopic.php?f=206&t=21696 Haynes Pro Full viewtopic.php?f=215&t=6793
RENAULT DIALOGYS 4.90 Français viewtopic.php?f=199&t=16332 Autodata 3.45 Français et Anglais viewtopic.php?f=202&t=3006 Jpro 2022 v2 + Activator viewtopic.php?f=215&t=24113 ElsaWin 6.0 Multilanguage viewtopic.php?f=190&t=12951
Renault Can Clip v236 + Activator 03.2024 viewtopic.php?f=212&t=24003 MaxiECU2 Full + License viewtopic.php?f=215&t=2393 Toyolex 4 Unlocked no need activation viewtopic.php?f=213&t=23442&p=135735 Immo Doctor v2.1 2023 + Keygen viewtopic.php?f=216&t=22367
Selling / Vente: Activation Launch x431 EasyDiag Golo + ThinkDiag viewtopic.php?f=137&t=14064 Xentry OpenShell 12.2023 HHT (+C3) WIS EPC Vediamo Monaco viewtopic.php?f=196&t=13346 Remote Install BMW ISTA-D, ISTA-P, INPA, E-Sys viewtopic.php?f=137&t=14739
How to Repair Toyota RAV4 Torque Converter Flex Lock-up Shudder
Automotive Scan Tools and Vehicle Diagnostics for sale
* Publier votre annonce gratuitement
* Post your ad for free
* Publier votre annonce gratuitement
* Post your ad for free
- Lemoine88
- Lieutenant.
- Messages : 63
- Enregistré le : lun. 8 août 2022 04:06
- Réputation : 20
- A été remercié : 40 fois
- Sexe :
- Zodiaque :
- Contact :
How to Repair Toyota RAV4 Torque Converter Flex Lock-up Shudder
Message par Lemoine88 » sam. 5 nov. 2022 03:29
I'm a Capricorn and I prefer my job。www.obd2.ltd
Répondre
1 message
• Page 1 sur 1
255 derniers membres ayant consulté ce sujet
ABB, Roman84, Bartekwww, bouba30, nycos388, rgmaster3, Lemoine88
Retourner vers « Vente Scanners et Outils Diagnostic Automobile »
Aller à
- Download Car / Truck GPS & Diagnostic Software
- ↳ Renault, Dacia, Opel et Vauxhall
- ↳ Attention ! Mise en Garde !
- ↳ Démonstration Mediaskin v2 et comparaison GPS Media Nav et Mediaskin
- ↳ MediaNav - Mise à Jour avec Upgrade et downgrade
- ↳ MediaNav - Installation du programme GPS
- ↳ MediaNav - Cartes GPS MediaNav à télécharger (Mise à jour en permanence)
- ↳ MediaNav - Autres fichiers gps
- ↳ MediaNav - Alerte Radars compatible avec media nav (Mise à jour en permanence)
- ↳ MediaNav - Personnalisation
- ↳ MediaNav - Installation Caméra de Recul sur Media Nav
- ↳ MediaNav - Réparation des Pannes et Documentation
- ↳ MediaNav - Réparation Pannes de Blocage sur Logo
- ↳ MediaNav - RGMaster3 SoftWares
- ↳ Mediaskin V2 et V3 - Installation avec Clé USB
- ↳ Mediaskin V2 - Installation sans Clé USB
- ↳ Mediaskin V2 - Installation des Thèmes ou Skins
- ↳ Mediaskin V2 - Réparation et Personnalisation
- ↳ Renault Dacia - Tutoriel Divers
- ↳ Renault / Dacia Tutoriels vidéos - Guide d'installation de la caméra de recul
- ↳ Renault / Dacia Tutoriels vidéos - Remise à zéro le voyant vidange du tableau de bord
- ↳ Autres Tutoriels vidéos
- ↳ R-Link / Renault
- ↳ R-Link 1
- ↳ R-Link 1 Tutoriels vidéos
- ↳ R-Link 2
- ↳ R-Link 2 Tutoriels vidéos
- ↳ Carminat / Renault
- ↳ Peugeot et Citroen
- ↳ Cartographies GPS
- ↳ Zones de danger avec cartographies GPS
- ↳ Firmwares - Mises à jours
- ↳ Identification des GPS
- ↳ Tutoriels
- ↳ Trucs et astuces
- ↳ GPS embarqués & firmwares / Autres Voitures
- ↳ Renault - Dacia
- ↳ Peugeot - Citroën
- ↳ Volkswagen - SEAT - SKODA
- ↳ BMW
- ↳ Mercedes
- ↳ Audi
- ↳ Kia
- ↳ GPS embarqués autres voitures
- ↳ GPS Android / iPhone / Windows CE, voitures et camions
- ↳ GPS Android / iPhone
- ↳ GPS Windows CE
- ↳ Logiciels de diagnostic voitures et camions
- ↳ Audi - Volkswagen- Seat - Skoda / Logiciels de Diagnostique
- ↳ Bmw / Logiciels de Diagnostique
- ↳ Buick - Cadillac - Chevrolet - GMC / Logiciels de Diagnostique
- ↳ Fiat - Lancia - Alfa Romeo / Logiciels de Diagnostique
- ↳ Ford - Land Rover - Jeep - Jaguar / Logiciels de Diagnostique
- ↳ Hyundai - Daewoo - Kia - SsangYong / Logiciels de Diagnostique
- ↳ Mercedes-Benz / Logiciels de Diagnostique
- ↳ Mitsubishi - Mazda - Suzuki - Daihatsu / Logiciels de Diagnostique
- ↳ Peugeot - Citroën / Logiciels de Diagnostique
- ↳ Renault - Dacia - Nissan / Logiciels de Diagnostique
- ↳ Toyota - Lexus - Honda / Logiciels de Diagnostique
- ↳ Volvo / Logiciels de Diagnostique
- ↳ Multimarques & Andriod OBD software / Logiciels de Diagnostique
- ↳ Multimarques, ECU - IMMO - Radio Code - Airbag / Logiciels de Diagnostique
- ↳ Documentation d'aide sur l'utilisation de l'outil de diagnostic
- ↳ Catalogue de pièces électroniques (EPC), RTA, manuel de maintenance et de diagnostic
- ↳ Catalogue de pièces électroniques (EPC) Automobile - Camion
- ↳ Audi - Volkswagen- Seat - Skoda / Logiciels
- ↳ Bmw / Logiciels
- ↳ Buick - Cadillac - Chevrolet - GMC / Logiciels
- ↳ Fiat - Lancia - Alfa Romeo / Logiciels
- ↳ Ford - Land Rover - Jeep - Jaguar / Logiciels
- ↳ Hyundai - Daewoo - Kia - SsangYong / Logiciels
- ↳ Mercedes-Benz / Logiciels
- ↳ Mitsubishi - Mazda - Suzuki - Daihatsu / Logiciels
- ↳ Peugeot - Citroën / Logiciels
- ↳ Renault - Dacia - Nissan / Logiciels
- ↳ Toyota - Lexus - Honda / Logiciels
- ↳ Volvo / Logiciels
- ↳ Multimarques / Logiciels
- ↳ E-book / Diagnostic, Mécanique et Revue Technique Auto
- ↳ Audi - Volkswagen- Seat - Skoda / Diag & Documentations
- ↳ Bmw / Diag & Documentations
- ↳ Buick - Cadillac - Chevrolet - GMC / Diag & Documentations
- ↳ Fiat - Lancia - Alfa Romeo / Diag & Documentations
- ↳ Ford - Land Rover - Jeep - Jaguar / Diag & Documentations
- ↳ Hyundai - Daewoo - Kia - SsangYong / Diag & Documentations
- ↳ Mercedes-Benz / Diag & Documentations
- ↳ Mitsubishi - Mazda - Suzuki - Daihatsu / Diag & Documentations
- ↳ Peugeot - Citroën / Diag & Documentations
- ↳ Renault - Dacia - Nissan / Diag & Documentations
- ↳ Toyota - Lexus - Honda / Diag & Documentations
- ↳ Volvo / Diag & Documentations
- ↳ Multimarques & Général Documents
- ↳ Diagnostic Général / Documentations
- ↳ Vente Scanners et Outils Diagnostic Automobile
- Softwares / Logiciels Win, iOS & APK
- Communauté motorcarsoft
- ↳ Signalez des problèmes
- ↳ Nouveautés, avis et suggestions à propos du site
- ↳ Discussions générales
- FAQ sur le forum
- Corbeille
- Nos partenaires